June 28, 2020
The crankcase is the lower part of the engine where the crankshaft is housed and where the engine oil lives. The crankshaft is connected to the pistons that power the engine.
When you are diving around Loves Park, fuel is burned in your vehicle engine, it pushes the pistons down and the crankshaft rotates and sends power to the transmission. Some of the explosive gases from combustion squeeze past the pistons and down into the crankcase.
Now this gas is about 70% unburned fuel. If it were allowed to remain in the crankcase, it would contaminate the oil and quickly turn it to sludge. Sludge is like Vaseline and clogs passages in the engine, leading to damage.
Also, the pressure build up would blow out seals and gaskets. So in the old days, there was just a hose that vented the crankcase out into the air. Obviously, not good for our air quality in Loves Park, Illinois.
Enter the PCV valve. It's a small, one-way valve that lets out the gases from the crankcase and routes them back into the air intake system where they are re-burned in the engine. Fresh air comes into the crankcase through a breather tube. This makes for good circulation in the crankcase. And that gets the air out. As you can imagine, however, the valve gets gummed up over time.
Your vehicle manufacturer usually recommends they be changed somewhere between 20,000 to 50,000 miles/30,000 to 80,000 kilometers. Unfortunately, PCV valve replacement is left out of some vehicle owner's manuals, but your friendly service advisor at Tuffy Rockford, we will make sure your PVC is replaced if needed.
Tuffy Rockford
6574 E. Riverside
Loves Park, Illinois 61111
815.639.1239
April 28, 2024
Many Loves Park car owners have probably wondered: "What's the harm in putting off replacing an engine air filter? The answer is that not replacing it could cause your Mass Air Flow (MAF) sensor to fail. This expensive sensor is situated between your engine air filter and your engine. Dirty air ... More
April 21, 2024
It's bad enough when you mistakenly leave a window open in your vehicle on a rainy day and you find your carpet soaked. But what in the world is going on when your windows are closed tight, not leaking and you STILL wind up with wet carpet? The answer could be something you might not even know y... More
April 14, 2024
Today's Tuffy Rockford article focuses on severe service maintenance. Many Loves Park drivers are not aware of them and yet there are also very vocal advocates in Illinois who think that severe service schedules apply to everyone. Somewhere between a complete lack of awareness and the dire blank... More